Product ID:ZR-10B REMOVER (HYDROPHILIC EMULSIFIER)
MSDS Date:07/17/1986
FSC:6850
NIIN:01-266-4549
Kit Part:Y
MSDS Number: BHQFV

MAGNAFLUX CORPORATION

7300 W.LAWRENCE AVENUE
CHICAGO, IL 60656-3504
US

Emergency Phone: 708-867-8000

Info Phone: 708-867-8000

Preparer: BRUCE C. GRAHAM, CH. CHEM

Cage: 37676

ILLINOIS TOOL WORKS INC MAGNAFLUX DIV

GLENVIEW, IL 60025 US

Telephone: 847-657-5300/

Cage: 37676

HEXYLENE GLYCOL

CAS: 107-41-5

RTECS: SA0810000

Fraction By Weight: 35.0%

OSHA PEL C 25 PPM

ACGIH TLV: C 25 PPM; 9192

"NOT HAZARDOUS"(MANUFACTURER STATED IN MSDS THAT ITEM

OSHA PEL NOT KNOWN

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:IRRITATES EYES.
Effects of Overexposure:INHALATION:CAUSES DIZZINESS,DROWSINESS,NAUSEA;
SKIN:LIQUID IRRITATES BY DISSOLVING SKIN OIL; EYES:VAPORS/LIQUID
CAUSES IRRITATION; INGESTION:NOT LISTED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:NOT KNOWN

First Aid:INHALATION:REMOVE TO FRESH AIR.IF BREATHING IS DIFFICULT,GIVE
OXYGEN; SKIN:REMOVE CONTAMINATED CLOTHES.WASH OFF WITH FLOWING
WATER.USE SOOTHING LOTION.IF IRRITATION PERSISTS,GET MEDICAL ATTN;
EYES:IMM EDIATELY RINSE/FLUSH WITH COPIOUS AMOUNT OF RUNNING
WATER,AND GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:200F/ 93C
Extinguishing Media:CARBON DIOXIDE,FOAM,WATER
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.

Spill Release Procedures:REMOVE IGNITION SOURCES.SM QTY:WIPE UP OR MOP
UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LG
QTY:WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCIAL ABSORBEN T.TRANSFER WASTE MATL IN SALVAGE
TANKS.

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.

Respiratory Protection:WEAR A RESPIRATOR WITH CHEMICAL CARTRIDGE. IN
CONFINED AREAS,WEAR A FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW TLV LIMITS.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Other Protective Equipment:EITHER USE IN A SPRAY BOOTH OR NEXT TO AN
EXHAUST VENT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
NSN FOR SET/KIT OF TYPE I,METHOD D,LEVEL 3 OF MIL-I-25135E;SET MAY
CONSIST OF ZL-27A OR ZL-22D PENETRANT AND ZR-10A OR ZR-10B
EMULSIFIER OF 20% CONCENTRATION AS SPECIFIED IN
QPL-25135-15;ZR-10A/ZR-10B REMOVER IS WATER SOLUBLE(HYDROPHILIC)
EMULSIFIER;THIS ENTRY DESCRIBES ZR-10B REMOVER.KEY1:N1.SEE OTHR PNI
FOR PENETRNT.

HCC:N1
Boiling Pt:B.P. Text:400F/204C
Vapor Pres:0.3 @100F
Vapor Density:1.0
Spec Gravity:0.9
pH:7.0
Solubility in Water:COMPLETE
Appearance and Odor:PINK OILY LIQUID

Stability Indicator/Materials to Avoid:YES
NOT KNOWN TO MFR
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES
Hazardous Decomposition Products:EMITS OXIDES OF CARBON AND NITROGEN.

Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS.IF LOCAL AUTHORITIES PROHIBIT
DUMPING RINSINGS DOWN THE SEWER,P URIFY RINSINGS WITH MAGNAFLUX
WASTEWATER SYSTEM.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.